岩石GFRP抗浮锚杆承载性能室内试验与机理分析
CSTR:
作者:
中图分类号:

TU475

基金项目:

国家自然科学基金(51708316、51778312);山东省重点研发计划(2017GSF16107、2018GSF117008);山东省自然科学基金(ZR2016EEQ08、ZR2017PEE006);山东省高等学校科技计划(J16LG02);青岛市应用基础研究计划(16-5-1-39-jch);中国博士后科学基金(2018M632641)


Full-scale test and mechanism analysis on bearing capacity of GFRP anti-floating anchor socketed into rock
Author:
  • 摘要
  • | |
  • 访问统计
  • |
  • 参考文献 [25]
  • |
  • 相似文献 [20]
  • | | |
  • 文章评论
    摘要:

    基于4根岩石GFRP抗浮锚杆的室内足尺拉拔破坏性试验,探讨了风化岩地基中全长黏结GFRP抗浮锚杆的界面黏结特性和承载性能,揭示了GFRP锚杆的细观破坏机理。结果表明:GFRP抗浮锚杆发生拔出破坏,主要是由螺纹表面劣化所引起的剪胀破坏;直径25 mm、灌浆体强度M30、锚固长度1.3和0.55 m的GFRP抗浮锚杆的极限抗拔承载力分别为255、195 kN,满足工程抗浮要求;GFRP抗浮锚杆杆体与灌浆体界面平均黏结强度介于2.41~5.10 MPa之间,高于《岩土锚固与喷射混凝土支护工程技术规范》(GB 50086—2015)中钢锚杆与灌浆体的黏结强度推荐值。

    Abstract:

    Based on the laboratory full-scale tensile failure tests on four full-bonded GFRP anti-anchors socketed into rock, the interfacial adhesion and bearing capacity of the anchor on rock foundation were studied, from which the micro-failure mechanism of the anchor was revealed. The results show that the pull-out failure occurred in GFRP anti-floating anchor, attributing to the dilative shear failure from anchor thread's interfacial deterioration. The ultimate uplift bearing capacity of GFRP anti-floating anchor with diameter of 25 mm, concrete of M30, anchorage length of 1.3 m and 0.55 m, was 255 kN and 195 kN, respectively, indicating that the high bearing capacity of the anchor for anti-floating purpose. The average bond strength between GFRP anti-floating anchor and grouting body was between 2.41 MPa and 5.10 MPa, higher than the recommended values from Technical Code for Engineering of Ground Anchoring and Shotcrete Support"(GB 50086-2015).

    参考文献
    [1] 朱磊, 张明义, 白晓宇, 等. GFRP抗浮锚杆在基础底板中的锚固性能现场试验研究[J]. 土木建筑与环境工程, 2017, 39(2):107-114. ZHU L, ZHANG M Y, BAI X Y, et al. Field test on anchorage performance of GFRP anti-floating anchors in foundation slab[J]. Journal of Civil, Architectural & Environmental Engineering, 2017, 39(2):107-114. (in Chinese)
    [2] 张明义, 朱磊, 白晓宇, 等. 钢筋抗浮锚杆外锚固承载性能试验研究[J]. 土木建筑与环境工程, 2016, 38(Sup1):118-124. ZHANG M Y, ZHU L, BAI X Y, et al. Experimental research on load bearing behavior of external anchorage of steel anti-floating anchors[J]. Journal of Civil, Architectural & Environmental Engineering, 2016, 38(Sup1):118-124. (in Chinese)
    [3] KOU H, GUO W, ZHANG M. Pullout performance of GFRP anti-floating anchor in weathered soil[J]. Tunnelling and Underground Space Technology, 2015, 49:408-416.
    [4] LIU X, WANG J, HUANG J, et al. Full-scale pullout tests and analyses of ground anchors in rocks under ultimate load conditions[J]. Engineering Geology, 2017, 228:1-10.
    [5] BENMOKRANE B, ALI A H, MOHAMED H M, et al. Laboratory assessment and durability performance of vinyl-ester, polyester, and epoxy glass-FRP bars for concrete structures[J]. Composites Part B:Engineering, 2017, 114:163-174.
    [6] VELJKOVIC A, CARVELLI V, HAFFKE M M, et al. Concrete cover effect on the bond of GFRP bar and concrete under static loading[J]. Composites Part B:Engineering, 2017, 124:40-53.
    [7] CARATELLI A, MEDA A, RINALDI Z, et al. Precast tunnel segments with GFRP reinforcement[J]. Tunnelling and Underground Space Technology, 2016, 60:10-20.
    [8] YOST J, DINEHART D, GROSS S, et al. Fatigue behavior of GFRP and steel reinforced bridge decks designed using traditional and empirical methodologies[J]. Bridge Structures, 2015, 11(3):87-94.
    [9] XU D, YIN J. Analysis of excavation induced stress distributions of GFRP anchors in a soil slope using distributed fiber optic sensors[J]. Engineering Geology, 2016, 213:55-63.
    [10] 刘汉东, 于新政, 李国维. GFRP锚杆拉伸力学性能试验研究[J]. 岩石力学与工程学报, 2005, 24(20):3719-3723. LIU H D, YU X Z, LI G W. Experimental study on tensile mechanical properties of glass fiber reinforced plastic rebar[J]. Chinese Journal of Rock Mechanics and Engineering, 2005, 24(20):3719-3723(in Chinese)
    [11] 贾新, 袁勇, 李焯芬. 新型玻璃纤维增强塑料砂浆锚杆的黏结性能试验研究[J]. 岩石力学与工程学报, 2006, 25(10):2108-2114. JIA X, YUAN Y, LEE C F. Experimental study on bond behavior of new type cement grouted GFRP bo1ts[J]. Chinese Journal of Rock Mechanics and Engineering, 2006, 25(10):2108-2114. (in Chinese)
    [12] 李国维, 高磊, 黄志怀, 等. 全长粘结玻璃纤维增强聚合物锚杆破坏机制拉拔模型试验[J]. 岩石力学与工程学报, 2007, 26(8):1653-1663. LI G W, GAO L, HUANG Z H, et al. Pull-out model experiment on failure mechanism of pull-length bonding glass fiber reinforced polymer rebar[J]. Chinese Journal of Rock Mechanics and Engineering, 2007, 26(8):1653-1663. (in Chinese)
    [13] ZHU H H, YIN J H, YEUNG A T, et al. Field pullout testing and performance evaluation of GFRP soil nails[J]. Journal of Geotechnical and Geoenvironmental Engineering, 2010, 137(7):633-642.
    [14] LI G W, PEI H F, HONG C Y. Study on the stress relaxation behavior of large diameter B-GFRP bars using FBG sensing technology[J]. International Journal of Distributed Sensor Networks, 2013, 9(10):1-12.
    [15] 白晓宇, 张明义, 刘鹤, 等. 风化岩地基全螺纹玻璃纤维增强聚合物抗浮锚杆承载特征现场试验[J]. 岩土力学, 2014, 35(9):2464-2472. BAI X Y, ZHANG M Y, LIU H, et al. Field test on load-bearing characteristics of full-thread GFRP anti-floating anchor in weather rock site[J]. Rock and Soil Mechanics, 2014, 35(9):2464-2472. (in Chinese)
    [16] VILANOVA I, BAENA M, TORRES L, et al. Experimental study of bond-slip of GFRP bars in concrete under sustained loads[J]. Composites Part B:Engineering, 2015, 74(1):42-52.
    [17] BENMOKRANE B, ROBERT M, MOHAMED H M, et al. Durability assessment of glass FRP solid and hollow bars (rock bolts) for application in ground control of Jurong Rock Caverns in Singapore[J]. Journal of Composites for Construction, 2016, 21(3):06016002.
    [18] 建筑基坑支护技术规程:JGJ 120-2012[S]. 北京:中国建筑工业出版社, 2012. Technical specification for retaining and protection of building foundation excavations:JGJ 120-2012[S]. Beijing:China Architecture and Building Press, 2012. (in Chinese)
    [19] LI C C, KRISTJANSSON G, HΦIEN A H. Critical embedment length and bond strength of fully encapsulated rebar rockbolts[J]. Tunnelling and Underground Space Technology, 2016, 59:16-23.
    [20] ZHENG J J, DAI J G. Analytical solution for the full-range pull-out behavior of FRP ground anchors[J]. Construction and Building Materials, 2014, 58:129-137.
    [21] NEMCIK J, MA S, AZIZ N, et al. Numerical modelling of failure propagation in fully grouted rock bolts subjected to tensile load[J]. International Journal of Rock Mechanics and Mining Sciences, 2014, 71:293-300.
    [22] 黄志怀, 李国维, 王思敬, 等. 不同围岩条件玻璃纤维增强塑料锚杆结构破坏机制现场试验研究[J]. 岩石力学与工程学报, 2008, 27(5):1008-1018. HUANG Z H, LI G W, WANG S J, et al. Field test on pullout behaviors of anchorage structures with glass fiber reinforced plastic rods for different surrounding rock masses[J]. Chinese Journal of Rock Mechanics and Engineering, 2008, 27(5):1008-1018. (in Chinese)
    [23] 岩土锚固与喷射混凝土支护工程技术规范:GB 50086-2015[S]. 北京:中国计划出版社, 2001. Technical code for engineering of ground anchorages and shotcrete support:GB 50086-2015[S]. Beijing:China Planning Press, 2015. (in Chinese)
    [24] 白晓宇, 张明义, 寇海磊. 基于裸光纤光栅传感技术GFRP抗浮锚杆荷载传递机制的原位试验研究[J]. 工程力学, 2015, 32(8):172-181. BAI X Y, ZHANG M Y, KOU H L. Field experimental study of load transfer mechanism of GFRP anti-floating anchors based on embedded bare fiber bragg grating sensing technology[J]. Engineering Mechanics, 2015, 32(8):172-181. (in Chinese)
    [25] 白晓宇. GFRP抗浮锚杆锚固机理试验研究与理论分析[D]. 山东青岛:青岛理工大学, 2015. BAI X Y. Experimental study and theoretical analysis on the anchoring mechanism for GFRP anti-floating anchor[D]. Qingdao, Shandong:Qingdao University of Technology, 2015. (in Chinese)
    引证文献
    网友评论
    网友评论
    分享到微博
    发 布
引用本文

白晓宇,张明义,王永洪,闫楠.岩石GFRP抗浮锚杆承载性能室内试验与机理分析[J].土木与环境工程学报(中英文),2018,40(5):78-85. Bai Xiaoyu, Zhang Mingyi, Wang Yonghong, Yan Nan. Full-scale test and mechanism analysis on bearing capacity of GFRP anti-floating anchor socketed into rock[J]. JOURNAL OF CIVIL AND ENVIRONMENTAL ENGINEERING,2018,40(5):78-85.10.11835/j. issn.1674-4764.2018.05.010

复制
分享
文章指标
  • 点击次数:1049
  • 下载次数: 986
  • HTML阅读次数: 541
  • 引用次数: 0
历史
  • 收稿日期:2017-11-03
  • 在线发布日期: 2018-08-11
文章二维码